Product ID:LOW IR EPOXY-POLYAMIDE PRIM, 46307034E
MSDS Date:09/20/1989
FSC:8010
NIIN:00N020659
MSDS Number: BLKLM

AKZO COATINGS INC

434 W MEATS ST
ORANGE, CA 92665
US

Emergency Phone: 313-589-3660; 313-855-7313

Info Phone: 313-589-3660

Cage: 98502

AKZO COATINGS INC

ORANGE, CA 92661 US

Telephone: 714-637-1750; CHEMTREC 800-424-9300

Cage: 98502

VARY FROM PERSON TO PERSON. AS A PRECAUTION, EXPOS

RTECS: 9999999ZZ

OVEREXP TO MATL HAS BEEN SUGGESTED AS A CAUSE OF

RTECS: 9999999ZZ

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 20-35%

OSHA PEL 150 PPM/200 STEL

ACGIH TLV: 150 PPM/200STEL;9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

SILICON DIOXIDE; (FLUX CALCINED DIATOMACEOUS EARTH

CAS: 68855-54-9

Fraction By Weight: 5-20%

HYDRATED IRON OXIDE

CAS: 20344-49-4

Fraction By Weight: <5%

OSHA PEL 10 MG/M3 TDUST

ACGIH TLV: 5 MG/M3 FUME

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 5-20%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE

CAS: 108-65-6

RTECS: AI8295000

Fraction By Weight: 5-20%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

SILICA; (AMORPHOUS SILICA)

CAS: 7631-86-9

Fraction By Weight: 5-20%

OSHA PEL 6 MG/M3 TDUST (MFR)

ACGIH TLV: 10 MG/M3 TDUST (MFR)

STRONTIUM CHROMATE (SARA III)

CAS: 7789-06-2

RTECS: GB3240000

Fraction By Weight: 15-30%

OSHA PEL 0.1 PPM CRO3;CEILING

ACGIH TLV: 0.0005MG CR/M3;A2;93

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5-20%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

WELD/FLAME CUT AN EMPTY DRUM. CONTAINS CHROMATE

RTECS: 9999999ZZ

& ADMIN CONTROLS MUST BE INSTITUTED TO MAINTAIN

RTECS: 9999999ZZ

OF A NIOSH/MSHA APPRVD RESP IS REC. DO NOT HANDLE

RTECS: 9999999ZZ

HEATING, REMOVE DECOMP PRODS FORMED DURING WELDING OR

RTECS: 9999999ZZ

RPTD&PRLNGD OCCUP OVEREXP TO SOLV W/PERM BRAIN &

RTECS: 9999999ZZ

LUNG DMG. HLTH STUDIES HAVE SHOWN THAT MANY PETRO

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:(ACUTE) EXCESS INHAL OF VAPS CAN CAUSE
NASAL & RESP IRRIT, DIZZ, WEAKNESS, FATG, NAUS, HDCH, POSS UNCON &
EVEN ASPHY. EYE CONT MAY CAUSE SEV IRRIT, REDNESS, TEARING, BLURRED
VISION & SENSATION OF SEEI NG HALOS AROUND LIGHTS. PRLNGD CONT
W/SKIN MAY LEAD TO EXTRACTION OF NATL OILS W/RESULTANT MILD (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IRRIT. IF SWALLOWED, CAN CAUSE GI
IRRIT, NAUS, VOMIT & DIARR. ASPIR OF MATL IN LUNGS CAN CAUSE CHEM
PNEUM WHICH CAN BE FATAL. EYE IRRITANT, CONT MAY CAUSE EYE
BURNS/CORNEAL INJURY. PRLNGD/RP TD CONT MAY CAUSE EYE IRRIT. VAPS &
FUMES MAY BE IRRIT TO UPPER RESP TRACT. DRY PIGMENT MAY CAUSE (SEE
SUPP DATA)
Medical Cond Aggravated by Exposure:NONE EXPECTED.

First Aid:INHAL: MOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. SKIN: WASH WITH SOAP AND WATER. EYE: FLUSH WITH WATER
FOR AT LEAST 15 MINUTES, CALL MD. INGEST: DRINK ONE OR TWO GLASSES
OF WATER TO DILUTE. DO NOT INDUCE VOMITING. CALL MD OR POISON
CONTROL CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.

Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1.2%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY BE INEFFECTIVE. WATER SHOULD BE
USED TO COOL CNTNRS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPARKS, ELEC EQUIP & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPSD TO EXTREME HEAT. APPLICATN TO HOT (SUPP DATA)

Spill Release Procedures:REFER TO PROTECTIVE MEASURES. REMOVE ALL
SOURCES OF IGNITION. AVOID BREATHING VAPORS. VENTILATE AREA. REMOVE
WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE CONTAINERS OUT OF SUN AND AWAY
FROM HEAT, SPARKS & OPEN FLAMES. CLOSE CONTAINERS AFTER EACH USE.
CONSULT NFPA CODE FOR ADDITIONAL STORAGE REQ.
Other Precautions:DO NOT TAKE INTERNALLY. USE APPRVD BONDING &
GROUNDING PROCEDURES. OBSERVE LABEL PREC. KEEP CLOSURES TIGHT &
CNTNR UPRIGHT TO PVNT LEAKAGE. NEVER USE PRESS TO EMPTY - DRUM IS
NOT A PRESS VESSEL. AVOID BRTHG SANDING DUST. DO NOT (SEE ING 9)

Respiratory Protection:ADEQUATE VENTILATION IS REQUIRED. USE NIOSH/MSHA
APPROVED RESPIRATOR DEVICE. SEE YOUR SAFETY EQUIPMENT SUPPLIER FOR
EVALUATION AND RECOMMENDATION. IN CONFINED AREAS USE NIOSH/MSHA
APPROVED AIRLINE RES PIRATOR OR HOOD.
Ventilation:PROVIDE SUFFICIENT VENT TO KEEP VAP CONC BELOW GIVEN TLV &
LEL. FOR BAKING FINISHES, EXHST VAPS EMITTED ON (SEE ING 12)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE BATH/SHOWER/CHEM RESIST
APRON/BOOTS/OTHER CLTHG IF NEEDED.LIQ MAY PENETRATE SHOES & LEATHER
CAUSING DELAYED IRRIT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
EXPLO HAZ: SURF REQ SPECIAL PREC. DURING EMER CNDTNS OVEREXP TO DECOMP
PRODS MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. CALL MD.
EFTS OF OVEREXP: NUISANCE DUST, WHICH CAN BE IRRIT TO RESP SYS TEM.
NOTICE: INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS MAY BE
HARMFUL/FATAL. RPTS HAVE ASSOC (SEE ING 13)

HCC:F3
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.313
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:60.4

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:CO, CO*2, SMOKE, NO*X.

Waste Disposal Methods:INCINERATE IN AN APPROVED FACICILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL POLLUTION CONTROL REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.